118-Point Service Program
Our standard contract includes one power generator service inspection and one maintenance inspection.
The following generator systems are checked as a part of your 118 point inspection:
| Battery Checks | |
| 1 | Battery Cables Checked |
| 2 | Battery Cable Terminals Cleaned and Checked |
| 3 | Battery Posts Cleaned and Checked |
| 4 | Electrolyte Level Checked and Topped Off |
| 5 | Charger Operation Checked |
| 6 | Charger Float Voltage Checked and Recorded |
| 7 | Battery Load Tested and Recorded |
| 8 | Date in Service Recorded |
| Cooling System Checks | |
| 9 | Fan Belt Checked |
| 10 | Alternator Belt Checked |
| 11 | Governor Belt Checked |
| 12 | Water Pump Belt Checked |
| 13 | Radiator Hoses Checked |
| 14 | Heater Hoses Checked |
| 15 | Radiator condition (Internal and External) Checked |
| 16 | Water Pump Checked |
| 17 | Coolant Level Checked and Topped Off |
| 18 | Coolant Protection Checked |
| 19 | Louver Operation Checked |
| 20 | All Hose Clamps Tightened |
| Lubrication Checks | |
| 21 | Oil Level, add if needed |
| 22 | Oil Condition Checked |
| 23 | Oil Lines Checked |
| 24 | Oil Filter Checked |
| Tune Up | |
| 25 | Plugs Checked |
| 26 | Points Checked |
| 27 | Condenser Checked |
| 28 | Distributor Cap Checked |
| 29 | Distributor Rotor Checked |
| 30 | Plug Wire's Checked |
| 31 | PCV Valve Checked |
| Exhaust System | |
| 32 | Piping Checked |
| 33 | Muffler Checked |
| 34 | Clear Condensate Drain |
| 35 | Insulation Check |
| 36 | Flex Pipe Check |
| 37 | Rain Cap Check |
| Fuel System | |
| 38 | Fuel Filter Check |
| 39 | Air Filter Check |
| 40 | Day Tank Check |
| 41 | Fuel Lines Checked |
| 42 | Fuel Solenoid Checked |
| 43 | Fuel Level Checked and Recorded |
| General System Checks | |
| 44 | Electrical Connections Checked |
| 45 | Mechanical Connections Checked |
| Operating Conditions | |
| 46 | Oil Pressure Recorded |
| 47 | Coolant Temperature Recorded |
| 48 | Engine Alternator Charging Voltage Recorded |
| 49 | AC Output Voltage Checked, Adjusted and Recorded |
| 50 | AC Output Frequency Checked, Adjusted and Recorded |
| 51 | AC Amps Recorded on Each Phase |
| Transfer Switch & System Test | |
| 52 | ATS Indicator Lamps Checked |
| 53 | ATS Meters Checked and Adjusted if Needed |
| 54 | Exercise Clock Checked |
| 55 | Exercise Clock Settings Checked and Recorded |
| 56 | Engine Start Time Delay Checked and Recorded |
| 57 | Transfer to Emergency Source Checked and Recorded |
| 58 | Retransfer to Normal Source Checked and Recorded |
| 59 | Engine Cool Down Time Delay Checked and Recorded |
| Engine Safeties | |
| 60 | Low Oil Pressure Pre-Alarm Checked |
| 61 | Low Oil Pressure Shut Down Checked |
| 62 | High Engine Temperature Pre-Alarm Checked |
| 63 | High Engine Temperature Shut Down Checked |
| 64 | Over Crank Safety Checked |
| 65 | Over Speed Safety Checked |
All of the following items are included in our Maintenance Visit:
| Maintenance Items | |
| 66 | Oil Changed |
| 67 | Oil Filter Changed |
| 68 | Oil Sample Taken if included with contract |
| 69 | Fuel Filters Changed |
| 70 | Air Filter Changed if Necessary |
| 71 | Spark Plugs Changed |
| 72 | Points Changed |
| 73 | Condenser Changed |
| 74 | Distributor Cap Changed |
| 75 | Distributor Rotor Changed |
| 76 | Lubricate Generator Bearing |
| 77 | Lubricate Governor Linkage |
| 78 | Lubricate Fan Shaft |
| 79 | Lubricate Water Pump Bearing |
| 80 | Inspect and Clean Slip Rings and Brushes |
| 81 | ALL 65 Checks Listed Under Service Inspection |
Note: All items on this list may not pertain to your emergency generator system, but on average, 118 of these points will be checked on your generator system.
